Пуско-зарядное устройство TELWIN Dynamic 520 Start. Инструкция на русском языке

Cod. 953665
MANUALE                GB..........pag. 02 NL...........pag. 16 RU.......... pag. 30 SI............pag. 45
I.............. pag. 04 DK..........pag. 19 H.............pag. 33 HR/SCG..pag. 47
RO..........pag. 36 LT........... pag. 49
F.............pag. 06 SF...........pag. 21
ISTRUZIONE             D.............pag. 09 N.............pag. 23  PL...........pag. 38 EE...........pag. 52
CZ...........pag. 41 LV...........pag. 54
E.............pag. 11 S.............pag. 26
SK.......... pag. 43 BG..........pag. 56
P.............pag. 14 GR..........pag. 28
GB    EXPLANATION OF DANGER.           RO    LEGENDA INDICATOARE DE
I     LEGENDA SEGNALI DI PERICOLO.           AVERTIZARE.
F     LEGENDE SIGNAUX DE DANGER.       PL    OBJASNIENIA SYGNALOW
D     LEGENDE DER GEFAHREN.                  ZAGROZENIA.
E     LEYENDA SENALES DE PELIGRO.      CZ    VYSVETLIVKY K SIGNALUM
P     LEGENDA DOS SINAIS DE PERIGO.          NEBEZPECI.
NL    LEGENDE SIGNALEN VAN GEVAAR.     SK    VYSVETLIVKY K SIGNALOM
DK    OVERSIGT OVER FARE.                    NEBEZPECENSTVA.
SF    VAROITUS, VELVOITUS.             SI    LEGENDA SIGNALOV ZA NEVARNOST.
N     SIGNALERINGSTEKST FOR FARE.      HR/SCG LEGENDA ZNAKOVA OPASNOSTI.
S     BILDTEXT SYMBOLER FOR FARA.      LT    PAVOJAUS ZENKLU PAAISKINIMAS.
GR    ??????? ??????? ????????.        EE    OHU KIRJELDUS.
RU    ЛЕГЕНДА СИМВОЛОВ
БЕЗОПАСНОСТИ.                   LV    BISTAMIBAS SIGNALU SARAKSTS.
H     VESZJELZESEK FELIRATAI.          BG    ЛЕГЕНДА СЪС СИГНАЛИТЕ ЗА
ОПАСНОСТ.
DANGER  OF  EXPLOSION  -  PERICOLO  ESPLOSIONE  -  RISQUE  D'EXPLOSION  -  EXPLOSIONSGEFAHR  -  PELIGRO
EXPLOSION  -  PERIGO  DE  EXPLOSAO  -  GEVAAR  ONTPLOFFING  -  SPR?NGFARE  -  RAJAHDYSVAARA  -  FARE  FOR
EKSPLOSJON  -  FARA  FOR  EXPLOSION  -  ????????  ???????  -  ОПАСНОСТЬ  ВЗРЫВА  -  ROBBANASVESZELY  -
PERICOL DE EXPLOZIE - NIEBEZPIECZENSTWO WYBUCHU - NEBEZPECI VYBUCHU - NEBEZPECENSTVO VYBUCHU -
NEVARNOST EKSPLOZIJE - OPCA OPASNOST - SPROGIMO PAVOJUS - PLAHVATUSOHT - SPRADZIENBISTAMIBA -
ОПАСНОСТ ОТ ЕКСПЛОЗИЯ.
GENERAL  HAZARD  -  PERICOLO  GENERICO  -  DANGER  GENERIQUE  -  GEFAHR  ALLGEMEINER  ART  -  PELIGRO
GENERICO - PERIGO GERAL - ALGEMEEN GEVAAR - ALMEN FARE - YLEINEN VAARA - GENERISK FARE STRALNING -
ALLMAN FARA - ??????? ???????? - ОБЩАЯ ОПАСНОСТЬ - ALTALANOS VESZELY - PERICOL GENERAL - OGOLNE
NIEBEZPIECZENSTWO - VSEOBECNE NEBEZPECI - VSEOBECNE NEBEZPECENSTVO - SPLOSNA NEVARNOST - OPCA
OPASNOST - BENDRAS PAVOJUS - ULDINE OHT - VISPARIGA BISTAMIBA - ОПАСНОСТ ОТ ОБЩ ХАРАКТЕР.
DANGER  OF  CORROSIVE  SUBSTANCES  -  PERICOLO  SOSTANZE  CORROSIVE  -  SUBSTANCES  CORROSIVES
DANGEREUSES  -  ATZENDE  GEFAHRENSTOFFE  -  PELIGRO  SUSTANCIAS  CORROSIVAS  -  PERIGO  SUBSTANCIAS
CORROSIVAS - GEVAAR CORROSIEVE STOFFEN - FARE, ?TSENDE STOFFER - SYOVYTTAVIEN AINEIDEN VAARA -
FARE:  KORROSIVE  SUBSTANSER  -  FARA  FRATANDE  AMNEN  -  ????????  ???????????  ??????  -  ОПАСНОСТЬ
КОРРОЗИВНЫХ  ВЕЩЕСТВ  -  MARO  HATASU  ANYAGOK  VESZELYE  -  PERICOL  DE  SUBSTANTE  COROSIVE  -
NIEBEZPIECZENSTWO WYDZIELANIA SUBSTANCJI KOROZYJNYCH - NEBEZPECI PLYNOUCI Z KOROSIVNICH LATEK -
NEBEZPECENSTVO  VYPLYVAJUCE  Z  KOROZIVNYCH  LATOK  -  NEVARNOST  JEDKE  SNOVI  -  OPASNOST  OD
KOROZIVNIH TVARI - KOROZINIU MEDZIAGU PAVOJUS - KORRUDEERUVATE MATERIAALIDE OHT - KOROZIJAS VIELU
BISTAMIBA - ОПАСНОСТ ОТ КОРОЗИВНИ ВЕЩЕСТВА.
Symbol indicating separation of electrical and electronic appliances for refuse collection. The user is not allowed to
dispose of these appliances as solid, mixed urban refuse, and must do it through authorised refuse collection centres. -
Simbolo che indica la raccolta separata delle apparecchiature elettriche ed elettroniche. L'utente ha l'obbligo di non
smaltire questa apparecchiatura come rifiuto municipale solido misto, ma di rivolgersi ai centri di raccolta autorizzati. -
Symbole indiquant la collecte differenciee des appareils electriques et electroniques. L'utilisateur ne peut eliminer ces
appareils avec les dechets menagers solides mixtes, mais doit s'adresser a un centre de collecte autorise. - Symbol fur die
getrennte Erfassung elektrischer und elektronischer Gerate. Der Benutzer hat pflichtgema? dafur zu sorgen, da? dieses
Gerat nicht mit dem gemischt erfa?ten festen Siedlungsabfall entsorgt wird. Stattdessen mu? er eine der autorisierten
Entsorgungsstellen einschalten. - Simbolo que indica la recogida por separado de los aparatos electricos y electronicos. El usuario tiene
la obligacion de no eliminar este aparato como desecho urbano solido mixto, sino de dirigirse a los centros de recogida autorizados. -
Simbolo que indica a reuniao separada das aparelhagens electricas e electronicas. O utente tem a obrigacao de nao eliminar esta
aparelhagem como lixo municipal solido misto, mas deve procurar os centros de recolha autorizados. - Symbool dat wijst op de
gescheiden inzameling van elektrische en elektronische toestellen. De gebruiker is verplicht deze toestellen niet te lozen als gemengde
vaste stadsafval, maar moet zich wenden tot de geautoriseerde ophaalcentra. - Symbol, der star for s?rlig indsamling af elektriske og
elektroniske apparater. Brugeren har pligt til ikke at bortskaffe dette apparat som blandet, fast byaffald; der skal rettes henvendelse til et
autoriseret indsamlingscenter. - Symboli, joka ilmoittaa sahko- ja elektroniikkalaitteiden erillisen kerayksen. Kayttajan velvollisuus on
kaantya valtuutettujen kerayspisteiden puoleen eika valittaa laitetta kunnallisena sekajatteena. - Symbol som angir separat sortering av
elektriske  og  elektroniske  apparater.  Brukeren  ma  oppfylle  forpliktelsen  a  ikke  kaste  bort  dette  apparatet  sammen  med  vanlige
hjemmeavfallet, uten henvende seg til autoriserte oppsamlingssentraler. - Symbol som indikerar separat sopsortering av elektriska och
elektroniska apparater. Anvandaren far inte sortera denna anordning tillsammans med blandat fast hushallsavfall, utan maste vanda sig
till  en  auktoriserad  insamlingsstation.  -  ???????  ???  ???????  ??  ???????????????  ???????  ???  ??????????  ???  ????????????
????????. ? ??????? ??????????? ?? ??? ?????????? ???? ?? ??????? ??? ????? ?????? ?????? ????????, ???? ?? ??????????? ??
???????????  ??????  ????????.  -  Символ,  указывающий  на  раздельный  сбор  электрического  и  электронного  оборудования.
Пользователь не имеет права выбрасывать данное оборудование в качестве смешанного твердого бытового отхода, а обязан
обращаться в специализированные центры сбора отходов. - Jeloles, mely az elektromos es elektronikus felszerelesek szelektiv
hulladekgyujteset jelzi. A felhasznalo koteles ezt a felszerelest nem a varosi tormelekhulladekkal egyuttesen gyujteni, hanem erre
engedellyel rendelkezo hulladekgyujto kozponthoz fordulni. - Simbol ce indica depozitarea separata a aparatelor electrice si electronice.
Utilizatorul este obligat sa nu depoziteze acest aparat impreuna cu deseurile solide mixte ci sa-l predea intr-un centru de depozitare a
deseurilor autorizat. - Symbol, ktory oznacza sortowanie odpadow aparatury elektrycznej i elektronicznej. Zabrania sie likwidowania
aparatury jako mieszanych odpadow miejskich stalych, obowiazkiem uzytkownika jest skierowanie sie do autoryzowanych osrodkow
gromadzacych odpady. - Symbol oznacujici separovany sber elektrickych a elektronickych zarizeni. Uzivatel je povinen nezlikvidovat
toto zarizeni jako pevny smiseny komunalni odpad, ale obratit se s nim na autorizovane sberny. - Symbol oznacujuci separovany zber
elektrickych  a  elektronickych  zariadeni.  Uzivatel  nesmie  likvidovat  toto  zariadenie  ako  pevny  zmiesany  komunalny  odpad,  ale  je
povinny dorucit ho do autorizovany zberni. - Simbol, ki oznacuje loceno zbiranje elektricnih in elektronskih aparatov. Uporabnik tega
aparata ne sme zavreci kot navaden gospodinjski trden odpadek, ampak se mora obrniti na pooblascene centre za zbiranje. - Simbol koji
oznacava posebno sakupljanje elektricnih i elektronskih aparata. Korisnik ne smije odloziti ovaj aparat kao obican kruti otpad, vec se
mora obratiti ovlastenim centrima za sakupljanje. - Simbolis, nurodantis atskiru nebenaudojamu elektriniu ir elektroniniu prietaisu
surinkima. Vartotojas negali ismesti siu prietaisu kaip misriu kietuju komunaliniu atlieku, bet privalo kreiptis i specializuotus atlieku
surinkimo  centrus.  -  Sumbol,  mis  tahistab  elektri-  ja  elektroonikaseadmete  eraldi  kogumist.  Kasutaja  kohustuseks  on  poorduda
volitatud kogumiskeskuste poole ja mitte kasitleda seda aparaati kui munitsipaalne segajaade. - Simbols, kas norada uz to, ka utilizacija
ir javeic atseviski no citam elektriskajam un elektroniskajam iericem. Lietotaja pienakums ir neizmest so aparaturu municipalaja cieto
atkritumu izgaztuve, bet nogadat to pilnvarotaja atkritumu savaksanas centra. - Символ, който означава разделно събиране на
електрическата и електронна апаратура. Ползвателят се задължава да не изхвърля тази апаратура като смесен твърд отпадък в
контейнерите за смет, поставени от общината, а трябва да се обърне към специализираните за това центрове.
- 1 -

_____________( GB )______________      2. INTRODUCTION AND GENERAL DESCRIPTION
-  This  battery  charger  can  be  used  to  charge  free
electrolyte lead acid batteries used on petrol and diesel
INSTRUCTION MANUAL
engine vehicles, motor cycles, boats etc.
- Accumulators rechargeable in accordance to the output
voltage available: 6V / 3 cells, 12V / 6 cells, 24V / 12 cells.
- The charging current delivered by the battery decreases
according  to  the  characteristic W  bend  -  see  the  DIN
WARNING: BEFORE USING THE BATTERY CHARGER   41774 norm.
READ THE INSTRUCTION MANUAL CAREFULLY.  - The charger case has a protection degree of IP 20 and is
protected against indirect contacts by an earth lead as
required for class  I  equipment.
1.  GENERAL  SAFETY  RULES  WHEN  USING  THIS
BATTERY CHARGER
3. INSTALLATION
ASSEMBLY (FIG.A)
-  Unpack the battery charger and assemble the separate
parts contained in the package.
- During the charge the battery produces explosive gases,   -  Models on wheels are to be set in a vertical position.
avoid  the  formation  of  flames  and  sparkes.  DO  NOT
SMOKE.                                POSITIONING THE BATTERY CHARGER
- Position the batteries to be charged in a well-ventilated   - During operation, position the battery charger on a stable
place.                                 surface and make sure that there is no obstruction to air
passage  through  the  openings  provided  to  ensure
sufficient ventilation.
CONNECTION TO THE MAIN SUPPLY
- The  battery  charger  should  be  connected  only  and
- Inexperience  and  untrained  people  should  be   exclusively  to  a  power  source  with  the  neutral  lead
properly instructed before using the appliance.  connected to earth.
- People (children included) whose physical, sensory   Check that the mains voltage is the same as the voltage of
or mental capacities would prevent them from using   the equipment.
the  appliance  correctly  must  be  supervised  by  a   - Check that the power supply is protected by systems such
person who is responsible for their safety while the   as fuses or automatic switches, sufficient to support the
appliance is in use.                   maximum absorption of the equipment.
- Children must be supervised to ensure that they do   - The connection to the main supply has to be made using a
not play with the appliance.           suitable cable.
- Use the battery charger only indoors and make sure that   - If you put an extension to the primary cable, the section
you start it in airy places. DO NOT SET IN THE RAIN OR   should be adequate and, in any case, never less than that
SNOW.                                  of the cable supplied.
- Disconnect  the  mains  cable  before  connecting  to  or   - You  always  have  to  earth  the  equipment  with  the
disconnecting the charging cables from the battery.  yellow/green wire contained in the main cable, indicated
- Do not connect or disconnect the clamps to or from the   by the label (  W
), while the other two wires should be
battery with the battery charger operating.  connected to the mains.
- Never  use  the  battery  charger  inside  the  car  or  in  the
bonnet.                              4. OPERATION
- Substitute the mains cable only with an original one.  BEFORE CHARGING
- Do not use the battery charger to charge batteries which   NB:  Before  charging  check  that  the  capacity  of  the
are not rechargeable.                battery (Ah) which is to be charged, is not inferior to that
-  Make  sure  the  available  power  supply  voltage   reported on the data table. (C min).
corresponds to that shown on the battery charger rating   Follow the instructions, taking great care to respect the
plate.
-  To avoid damaging the vehicle's electronics, read, keep   order given below.
and take very careful note of the information supplied by   - Remove the caps of the battery charger (if foreseen) so as
to let the gas produced go out.
the vehicle manufacturer, when using the battery charger
either for charging or starting; the same applies to the   - Check that the level of the electrolyte covers the plates of
instructions supplied by the battery manufacturer.  the battery. If these were not covered add distilled water
- This battery charger has components such as switches   and cover them up to 5-10 mm.
and  relays  which  can  cause  arcs  or  sparks. Therefore
when using it in a garage or in a similar place set the    WARNING: USE THE MAXIMUM CAUTION DURING
battery charger in a suitable case.   THIS OPERATION AS THE ELECTROLYTE IS A HIGHLY
- Repair or maintenance of the inside of the battery charger   CORROSIVE ACID.
can be executed only by skilled technicians.  -  Please  remember  that  the  exact  charge  status  of  the
- WARNING:  ALWAYS  DISCONNECT  THE  POWER   battery can only be determined by using a densimeter
SUPPLY  CABLE  FROM  THE  MAINS  BEFORE   which allows measurement of the specific gravity of the
CARRYING  OUT  ANY  SIMPLE  MAINTENANCE   electrolyte  the  following  indicate  approximate  density
OPERATION ON THE BATTERY CHARGER.      values for the solute (Kg/l at 20°c):
- Make  sure  the  power  outlet  is  protected  by  an  earth   1.28 = charged battery
connection.                                     1.21 = half-charged battery
- For models supplied without plugs, connect plugs having   1.14 = flat battery
a capacitance suitable for the value of the fuse shown in
the plate; for models supplied with cable and plug and with   -  With the power supply cable disconnected from the main
a "P.MAX START" power higher than 9kW, when used for   power supply outlet, position the 6/12 V or 12/24 V switch
starting, we advise replacing the plug with one having a   (if present) according to the rated voltage of the battery to
capacitance suitable for the fuse shown in the plate.   be charged.
-  Position the switch/es for adjusting the type of charge (if
- 2 -

present)  as  required  (FIG.B.  LOW  normal  charging,
HIGH rapid charging).                 END OF CHARGE
-  Check the polarities of the battery terminals: positive for   -  Remove  the  power supply  from  the  battery  charger  by
the + symbol and negative for the - symbol.  turning the switch to OFF (if present) and/or removing the
NOTE:  if  the  symbols  are  indistinguishable  remember   power supply cable from the mains outlet.
that the positive terminal is the one not connected to the   -  Disconnect the black charge clamp from the chassis of the
vehicle chassis.                       vehicle  or  from  the  negative  terminal  of  the  battery  (-
-  Connect the red charge clamp to the positive terminal of   symbol).
the battery  ( + symbol).             -  Disconnect  the  red  charge  clamp  from  the  positive
-  Connect the black charge clamp to the vehicle chassis, at   terminal of the battery  (+ symbol).
a safe distance from the battery and the fuel pipe.  -  Store the battery charger in a dry place.
NOTE: if the battery is not installed in the vehicle, connect   -  Close up the battery cells with the appropriate plugs (if
the clamp directly to the negative terminal of the battery (-   present).
symbol).
STARTING
CHARGE                                  Before  starting  the  vehicle,  make  sure  the  battery  is
-  Power the battery charger by inserting the power supply   connected properly to the respective (+ and -) terminals,
cable  into  the  power  outlet  and  turning  the  switch  (if   and that it is in good condition (not sulphated or dud).
present) to ON.                       Never  ever  start  vehicles  with  the  batteries
-  The  ammeter  (if  present)  will  indicate  the  current  (in   disconnected  from  their  respective  terminals;  the
Amps) delivered towards the battery: during this phase   presence of the battery is essential for the elimination of
the pointer of the ammeter will decrease slowly to very   possible  overvoltage  that  may  be  generated  due  to
low values according to the capacity and condition of the   energy  accumulating  in  the  connection  cables  at  the
battery.                             starting stage.
FIG.C                 For starting turn the switch to the start position at the voltage
corresponding to that of the vehicle being started.
NOTE: Once the battery is charged you may note the liquid   FIG. E
inside the battery starting to “boil”. It is advisable to stop   It is essential, before turning the ignition key, to make a rapid
charging when this phenomenon appears so as to prevent   charge for 5-10 seconds, which will greatly facilitate starting.
damage to the battery.                 Rapid charging should always be done with the battery
charger  switched  to  the  charge  position  and  NOT  to
AUTOMATIC CHARGING                     starting.
FOR MODELS WHERE PROVIDED:             It is possible to enable starting by pressing the remote control
1- Switch in automatic position. (    TRONIC)  button (only for 3-phase).
This  charging  mode  is  advisable  for  hermetic   The current supplied is indicated on the scale of the ammeter
with greater capacity.
batteries (GEL/AGM).
During  this  phase  the  battery  charger  will  constantly    WARNING: Before proceeding with starting follow the
monitor the voltage over the ends of the battery and will
automatically deliver or cut off the charge current towards   vehicle manufacturer's instructions carefully!
- Make  sure  the  power  line  is  protected  by  fuses  or
the battery.
automatic circuit-breakers with sizes as indicated on the
2 Switch in manual position.  (  CHARGE )  rating plate by the (  ) symbol.
This charging mode is advisable for WET batteries.  - In  order  to  prevent  overheating  in  the  battery  charger,
In this position automatic operation is deactivated.  ALWAYS carry out the starting operation according to the
For any other information relative to the charging system   duty cycle (work/pause) as indicated on the appliance (e.g.
of the battery please refer to the instruction manual.  START 3s ON 120s OFF-5 CYCLES). Do not insist if the
engine does not start: this could cause serious damage to
WARNING: SEALED BATTERIES (GEL/AGM)      the  battery  or  even  to  the  electrical  equipment  in  the
vehicle.
If it is necessary to charge this type of battery take
great care. Charge slowly keeping an eye on the voltage   5. BATTERY CHARGER PROTECTIONS (FIG. F)
over  the  battery  terminals. This  voltage  can  be  read   The battery charger has a safeguard that triggers in the case
easily using a normal tester and when it reaches 14.4V   of:
for 12V batteries (7.2V for 6V batteries and 28.8V for 24V   - Overload (excessive current supplied to the battery).
batteries)  we  recommend  terminating  the  charging   - Short circuit (charge clamps in contact with one another).
- Polarity inversion on battery terminals.
process.                               - For appliances fitted with fuses, if the fuses have to be
For models where foreseen, it is advisable to set the   replaced always use the same kind of fuse with the same
automatic function "TRONIC".
rated size.
SIMULTANEOUS CHARGING OF SEVERAL BATTERIES    WARNING: If the replacement fuse has a different
This  operation  must  be  performed  with  great  caution:
WARNING; do not simultaneously charge different types of   size from that shown on the rating plate it could cause
batteries  or  batteries  with  different  capacities  or  levels  of   damage  to  people  or  property.  For  the  same  reason,
discharge.                             never ever replace the fuse with a bridge in copper or
If you have to charge more than one battery at the same time   other material.
you can connect them “in series” or “in parallel”. Between the   The  power  supply  cable  should  always  be
two systems, we recommend connection in series because   DISCONNECTED from the mains supply while the fuse is
you can easily check the current charging each battery, as it   being changed.
will be the same as that shown by the ammeter.  When  replacing  the  ribbon  fuse,  if  present,  carefully
fasten the nuts.
NOTE:  If  two  batteries  with  rated  voltages  of  12V  are
connected in series, the battery charger MUST be set to the   6. USEFUL ADVICE
24V position.                          - If the positive and negative terminals are incrusted with
FIG. D                   oxide,  clean  them  to  ensure  good  contacts  with  the
- 3 -